1st Gear pops out
-
Hello Guest, we are proud to now have our Wiki online that is completely compiled and written by our members. Feel free to browse our Jeep-CJ Wiki or click on any orange keyword when looking at posts in the forum.
1st Gear pops out
- Thread starter mycj7
- Start date Start date:
- Last post Last post:
Hedgehog
Always Off-Roading Jeeper
- Posts
- 9,370
- Thanks
- 4
- Location
- Tucson/Marana Arizona
- Vehicle(s)
- -1975 Jeep CJ5, 360 V8, Headers, Duel Exhaust,T15 transmission, D-20 Transfer case, Twin Stick Conversion, Warn 8274 Winch
-1951 Willys Wagon, 4 cylinder, "F" head, little rust, very close to stock
Time for a rebuild. Probably a blown syncro.
You might get advice like: Check your motor mounts ..... It could be your Transmission mount ....... clutch, throwout bearing, bad bearings and other stuff, but 99% of the time you need a rebuild. Before I did that I'd research the Transmission you have. Some transmissions in the 1980's simply aren't worth a rebuild. I.E. fix'em and they quickly break again. The transmissions were simply to lightly built.
You might get advice like: Check your motor mounts ..... It could be your Transmission mount ....... clutch, throwout bearing, bad bearings and other stuff, but 99% of the time you need a rebuild. Before I did that I'd research the Transmission you have. Some transmissions in the 1980's simply aren't worth a rebuild. I.E. fix'em and they quickly break again. The transmissions were simply to lightly built.
Torxhead
Always Off-Roading Jeeper
I also think you need that overhaul, the aluminum cased transmissions for the later CJs were weak at best. I am quite suprised at the guys who still use them. I had a problem once where it would slip out of second gear whenever I let off the gas, the tranny overhaul fixed it.
7D8CJ
Active Jeeper
- Posts
- 291
- Media
- 48
- Thanks
- 0
- Location
- Crown Point ,IN
- Vehicle(s)
- 1978cj7 glass tub tilt front end 4.5" Rubicon Express lift 304 DUI Holly truck avenger T150 D20 33's , 2010 Rubicon JKU, 2015 WRX
I would at least make sure it's full of oil first. Then rebuid it.
mycj7
Jeeper
Thanks guys. Any ideas on rebuild vs new Transmission cost?
Hedgehog
Always Off-Roading Jeeper
- Posts
- 9,370
- Thanks
- 4
- Location
- Tucson/Marana Arizona
- Vehicle(s)
- -1975 Jeep CJ5, 360 V8, Headers, Duel Exhaust,T15 transmission, D-20 Transfer case, Twin Stick Conversion, Warn 8274 Winch
-1951 Willys Wagon, 4 cylinder, "F" head, little rust, very close to stock
You need to give us more information about your Jeep. Engine, Transmission , tire size any modifications, all of it is important for this discussion.
Naturally for a same/same Transmission change rebuilding would be less expensive. However that might not be the best choice. There are LOTS of Transmission options to consider. Go to the Novak web site and start reading, Advanced Adaptors is another good site.
Naturally for a same/same Transmission change rebuilding would be less expensive. However that might not be the best choice. There are LOTS of Transmission options to consider. Go to the Novak web site and start reading, Advanced Adaptors is another good site.
Torxhead
Always Off-Roading Jeeper
This would be a great time for an upgrade, but that depends what you want your rig for.
BusaDave9
Always Off-Roading Jeeper
- Posts
- 8,248
- Featured
- 3
- Media
- 361
- Resources
- 2
- Thanks
- 90
- Location
- Durango, Crawlarado
- Vehicle(s)
- 1979 Jeep CJ5 with 304 V8, T18 Transmission, Dana 20 Transfer case with TeraLow 3:1 gears, 4.88 axle gears, Detroit Locker up front and Ox Locker in back with 1 piece axle shafts, 36" SuperSwamper SX Tires, Shackle reversal, MileMarker Hydraulic winch, MSD 6A ignition.
Do you know what Transmission you have?
As Torxhead and others have said, you may want to upgrade. The T-176 was the best Transmission of the 80's. That would be the easiest swap but the lengths of the driveshafts would need to be modified. I am assuming you don't have a T-176 already. Buyers would need to specify the heavy duty Transmission to get one but they are not rare.
Check out this link: http://www.jeep-cj.com/forums/f105/manual-cj-transmissions-12112/#post97094
When I was in your shoes I swapped out a T-5 Transmission for a Ford T-18 . That's an excellent tranny. It's a truck Transmission and it shifts as such. Maybe that's more than you need but it's a great Transmission for off-roading.
As Torxhead and others have said, you may want to upgrade. The T-176 was the best Transmission of the 80's. That would be the easiest swap but the lengths of the driveshafts would need to be modified. I am assuming you don't have a T-176 already. Buyers would need to specify the heavy duty Transmission to get one but they are not rare.
Check out this link: http://www.jeep-cj.com/forums/f105/manual-cj-transmissions-12112/#post97094
When I was in your shoes I swapped out a T-5 Transmission for a Ford T-18 . That's an excellent tranny. It's a truck Transmission and it shifts as such. Maybe that's more than you need but it's a great Transmission for off-roading.
Hedgehog
Always Off-Roading Jeeper
- Posts
- 9,370
- Thanks
- 4
- Location
- Tucson/Marana Arizona
- Vehicle(s)
- -1975 Jeep CJ5, 360 V8, Headers, Duel Exhaust,T15 transmission, D-20 Transfer case, Twin Stick Conversion, Warn 8274 Winch
-1951 Willys Wagon, 4 cylinder, "F" head, little rust, very close to stock
Similar threads
-
Question
Reply's are voted
on for best answer
-
Question
Reply's are voted
on for best answer
Trans
2nd gear synchro?
-
Question
Reply's are voted
on for best answer
Trans
Grinding gears
-
Question
Reply's are voted
on for best answer
-
Question
Reply's are voted
on for best answer
Trans
T15 shifter frozen up
