Engine Jeep Soup Oil Leak

[Jeep Soup]

Had Jeep Soup out for a long run on Memorial Day. Jeep Soup has Always had a weeping rear crank seal. But NOW she is saying .....
I'm Done !!
Stop to top off the gas tank, left a serious Witness Mark at the Gas Pumps. Then it would leave a Witness Mark even at "Long Traffic Lights". Had to add a Quart at a Park Visit Stop.
Made it home OK, but it leaked out 2 more quarts. The Chassis is well lubricated !!

So, had to search for a Rear Crank Seal, and MOST important,
Someone with one In Stock!!
Don't forget, I'm leaving on the 9th for the Transmission Wisconsin Adventure Trail Rallye.

Finally found one from "Crown", and pan gaskets too.
The reviews on the "Crown" seal are mixed. Some are having OK results, others Not So Good.
I think part of it is the Quality of the Installation.

Well I have the oil pan off, and
Cleaned off the old Petrified Cork Gasket. So far found two things.
This has been worked on before,
by some Farmer Fixer.
One, the right side Round Stick Seal on the Rear Bearing Cap was sticking out, and Not Cut Flush to get the pan gasket to seal.
Two, I can not see the one on the Left Side in the hole.
I will find out more tomorrow morning when I pull the Rear Bearing Cap.

I will change the filter too, even though it only has 700 or so miles on a Oil change.

 

[Jeep Soup]

Now this is the Crown Rear Seal Kit as it arrived Yesterday.

These ends will have to be Cleaned Up True with a Razor Blade. And I will be using a Quality RTV sealant at this joint.
I will review staggering the Joints in the Cap and Block. I will check for how well it Compresses the Seals "Roundness" in the Cap First.
I'm letting everything drip into a catch pan overnight to save me from wearing most of it.




Tomorrow, the FUN PART!!
Getting the old seal out.....

 

[Belizean]

Hopefully you get it figured out before your trip. Luckily you have a backup vehicle just in case.

 

[Jeep Soup]

Hopefully you get it figured out before your trip. Luckily you have a backup vehicle just in case.

Yes I Do ......
I could take my Grand Cherokee and Sacrifice it to "Pin Stripe Alley" from trail brush.

Or Take the Timber Cruiser a 1987 Samurai build for such things.

And I DO Have a Pintel Hitch for it to Pull the M416 trailer. Just have to swap out the Light Bulbs to 12 volt.

 

[Belizean]

Yeah I was thinking Suzi Suzuki.

 

[Jeep Soup]

HA !
Suzi Suzuki ......
Funny is that is how the Timber Cruiser got It's camo paint job!!

Previous Owner was my Neighbor's Girlfriend (now wife).
It was White with Pinkish Purple Fenders!!
I would have LOST All My Man Points Driving that around !!